CARDAMOM PROCESSING
Introduction
Cardamom is a valuable spice that is obtained from the seeds of a perennial plant (Elettaria cardamomum). Cardamom originates from the coastal area of India. It is now grown in Guatemala, Tanzania, Sri Lanka, El Salvador, Vietnam, Laos and Cambodia. India is the main exporter of dried cardamom. Cardamom must be dried before it is stored and sold for market. This brief outlines the important steps that should be taken pre-harvest and post-harvest to ensure that the dried cardamom is of top quality for the market.
Figure 1: Small green cardamom (Eletteria cardamomum).
Photo credit: Neil Noble / Practical Action.
Types of cardamom
There are two main types of cardamom: Small green cardamom (Eletteria cardamomum) Large red/black cardamom (Amomum subulatum Roxb) The most common type is the small green cardamom while large cardamom is mainly grown in India, with some in Nepal and Bhutan. They both come from the Zingiberaceae family of plants.
Cardamom production
The Cardamom bush grows to a height of about 3m. It grows best in a warm humid place w here there is plenty of rain and rich soil. It can grow at altitudes up to 1370m above sea level. The bush requires shade and is usually grown under natural forest cover. The tree produces flowers after it is 2-3 years old. The first crop of seed capsules is harvested in the third year after planting. In India, the tree flowers in April/May and continues until July/August. The seed capsules are harvested at 30 to 40 day intervals.
Harvesting
Harvesting at the correct stage of maturity is essential to produce high quality car damom capsules. The fruits should only be harvested once they are fully r ipe and mature. In some places, farmers harvest the crop before it is fully ripe because they worry that it will be taken by thieves. If the crop is picked when it is mature, the higher yields and higher value of the final product may offset the losses due to theft. A ripe capsule has black seeds inside. An immature capsule has white seeds. When a cardamom capsule is ripe it can be easily removed from the stem of the plant without too much force. The harvester should start harvesting at the base of each stem and move up the stem, taking off any capsules that easily fall off without pulling. The capsules that do not fall off easily should be left on the plant to ripen.
Practical Action, The Schumacher Centre, Bourton on Dunsmore, Rugby, Warwickshire, CV23 9QZ, UK T +44 (0)1926 634400 | F +44 (0)1926 634401 | E infoserv@practicalaction.org.uk | W www.practicalaction.org ___________________________________________________________________________________________________________ Practical Action is a registered charity and company limited by guarantee. Company Reg. No. 871954, England | Reg. Charity No.247257 | VAT No. 880 9924 76 | Patron HRH The Prince of Wales, KG, KT, GCB
Cardamom processing
Practical Action
Cleaning
The crop should be cleaned before processing. The first stage is to remove dust and dirt using a winnowing basket. This can be made locally from bamboo, palm or other leaves. A worker who is used to doing this can clean up to 100kg of cardamom in an eight hour day. Small machines are available for cleaning, but they are often not cost effective. After winnowing the capsules are washed in clean water. Two or three large plastic buckets (15 litre capacity) are sufficient for small amounts but for large quantities, it may be better to use a sink with a drainage hole. Only water that is safe to drink should be used. It should be changed regularly to prevent contamination.
Pre-treatment
After washing, the stalks are removed from the cardamom capsules by hand. The capsules can be soaked in a solution of sodium bicarbonate (2 -5%) for ten minutes to help retain the green colour. This is an optional step. A 2% solution of sodium bicarbonate is prepared by dissolving 20g (about 4 tea spoons) of sodium bicarbonate in 1 litre of water.
Drying
This is the most important part of the process as it affects the quality of the final product. It is important to dry the cardamom capsules as soon after harvest as possible to prevent the loss of flavour. It is also important that the drying process is as short as possible so that mould does not grow on the capsules and the bright green colour is retained. The drying temperature should not be above 50°C as this affects the colour and delicate flavour of the final product. In most places, cardamom capsules with a good green colour can be sold for a premium price. The moisture content of a fresh cardamom capsule is about 85%. This needs to be reduced to 10% in the dried product so the cardamom capsules can be stored. If the drying period is too long mould can start to grow on the cardamom. There are several options available to the smallscale processor, depending upon the size of the business and the local weather conditions at the time of processing. Each method has different advantages and disadvantages: Sun drying. Traditionally, cardamom capsules are spread on a concrete floor to dry using the natural heat from the sun. The capsules should be placed away from direct sunlight to preserve the green colour (strong sunlight will make the colour fade). This is the simplest and cheapest method, but does not produce the highest quality product. It is only successful in places where the climate is dry and hot. During the monsoon season for example, drying will be in terrupted by rainfall which can cause mould to grow on the capsules. During drying, the capsules may be contaminated by dirt and dust from their surroundings. Solar drying . The use of a solar dryer should improve the quality of the dried capsules as it is a cleaner, more controlled environment. However, it is not a popular choice as the green colour is lost during drying. The solar dryer is really only useful in dry hot sunny climates. The capsules should be placed in the dryer, out of direct sunlight , and dried until they have a final moisture content of 10%. In places with high humidity the solar dryer can only be used together with an extractor fan to remove the humid air. Wood-fired dryer . In India, cardamom capsules are traditionally dried in curing houses, using wood to provide the heat. This method puts a huge demand on firewood. The smoke from the fire can give the capsules an unpleasant smoked flavour. The processor must ensure that the capsules closest to the heat source are not burnt or scorched. Cardamom capsules dried by this method are not of the highest quality.
Figure 2: A typical tray dryer 2
Cardamom processing
Practical Action
Electric or gas dryer . An electric or gas-fired dryer is an improvement over the use of a woodfuelled fire and is the best choice for drying large quantities of cardamom, especially in places where there is rainfall during the drying season. It is the most expensive of all options but does produce the highest quality product. It is important that the drying temperature does not exceed 50°C. A range of dryers of different sizes are available depending upon the individual choice and budget. Figure 2 shows a typical tray dryer. Humidity-controlled drying . A drying chamber has been developed that helps to reduce colour loss and to produce high quality pods. The cardamom capsules are placed in the drying chamber, which is at a temperature of 50 °C. During the first two hours of drying, the humidity builds up within the chamber. This allows the cardamoms to ‘cook’ and at the same time destroys the enzymes that break down the chlorophyll (chlorophyll gives the pods their green colour). No light is allowed into the drying chamber. After two hours the humid air is blown out of the chamber and the humidity reduced. The capsules are left in the chamber to dry until they have a final moisture content of 10%. Figure 3 shows a traditional drying chamber.
Figure 3: A traditional drying chamber
The use of biomass gasifiers Electricity and liquefied petroleum gas (LPG) are clean and convenient fuels for drying, but are not cheap or easily available in villages. Firewood, stubble and dry leaves are readily available in villages, but they are smoky and can contaminate the dried product. A gasifier is a device that has been developed by TERI (The Tata Energy Research Institute in India) for use in the drying of cardamom. The gasifier uses briquettes that are made from firewood and other types of biomass and turns them into a gas that burns with a clean smokeless flame. The main advantages of using a gasifier is that it is more efficient in terms of the amount of fuel used. Biomass that burns in an open fire loses about two thirds of its energy as smoke. This system therefore uses less fuel and produces a higher quality dried cardamom. The gasifier for drying cardamom, developed by TERI, can be made locally using recycled oil drums. For more information contact TERI (www.teriin.org).
Grading
Cardamom is graded by colour and size. The deeper the green colour and the larger the capsule size, the higher the grade. All grading is done by hand. The Indian grading system for cardamom capsules separates them into different types: Alleppey Green Cardamom Coorg Green Cardamom Bleached or Half-bleached Cardamom Bleached White Cardamom Mixed Cardamom
3
Cardamom processing
Practical Action
Agmark Schedule I for Alleppey Green Cardamom
Grade Trade name Colour Empty and malforme d capsules (%) 2.0 Immature and shrivelled capsules (%) 2.0 Blacks and splits (%) Size (diameter of sieve hole mm) Weigh t (G/L) General characteristics
AGEB
Cardamo m extra bold Cardamo m bold Cardamo m superior Shipment green-1 Shipment green-2 Light
AGB AGS AGS-1 AGS-2 AGL AGN
Deep green or light green As above As above As above As above -
0.0
7.0
435
2.0 3.0 5.0 7.0 -
2.0 5.0 7.0 9.0 -
0.0 0.0 10.0 12.0 15.0 -
6.0 5.0 4.0 4.0 3.5 -
415 385 350 320 260 -
Cardamoms are the dried capsules of Elletaria grown in South India. The capsules have 3 corners and a ribbed appearance. The capsules are free of insect damage and visible mould. Thrip marks on the capsules do not mean the capsules are infested with insects.
Definition of terms 1. Empty and malformed capsules : Capsules which have no seeds or are scanty filled with seeds. To measure this, 100 capsules are selected at random from the sample, opened and the number of empty and malformed capsules are counted. 2. Immature and shrivelled capsules : Capsules which are not fully developed. 3. Black and splits : The former includes capsules that have a visible blackish colour and the latter include those which are open at the corners for more than half th e length. 4. Colour : Cardamom are packed separately according to the colour: deep green, green, light green and pale brownish. If 95% of the cardamoms correspond to one of the colour groups, the relevant colour of the cardamom should be indicated on the Agma rk labels. When the cardamoms are not of any one uniform colour, the colour is not indicated on the label. 5. AGN: Cardamom that does not conform to any of the grades from AGEB to AGL is packaged under the grade AGN (Non-specified) Agmark Schedule II for Co org Green Cardamom
Grade Trade name Empty and malformed capsules (%) 0.0 2.0 3.0 5.0 Unclippe d capsules (%) 0.0 0.0 0.0 3.0 Immature and shrivelled capsules (%) 0.0 3.0 5.0 10.0 Blacks and splits (%) 0.0 0.0 0.0 0.0 Size (diameter of sieve hole mm) 8 .0 7.5 6.5 6.0 Weight (G/L) General characteristics
CGEB CGB CG1 CG2
CG3 CG4 CGN
Extra bold Bold Superior Coorg green or Motta green Shipmen t Light
450 435 415 385
10.0 -
5.0 -
15.0 -
10.0 15.0 -
5.0 3.5 -
350 280 -
Cardamoms are the dried capsules of Elletaria grown in South India. Colour range from greenish to brown. Global shape, skin ribbed or smooth, pedicels separated.The capsules have 3 corners and a ribbed
4
Cardamom processing
Practical Action
appearance. The capsules are free of insect damage and visible mould. Thrip marks on the capsules do not mean the capsules are infested with insects.
Definition of terms 1. Empty and malformed capsules : Capsules which have no seeds or are scanty filled with seeds. To measure this, 100 capsules are selected at random from the sample, opened and the number of empty and malformed capsules are counted. 2. Immature and shrivelled capsules : Capsules which are not fully developed. 3. Black and splits : The former includes capsules that have a visible blackish colour and the latter include those which are open at the corners for more than half the length. 4. Unclipped capsules : Capsules in which the tips have not been trimmed . 5. CGN: Cardamom that does not conform to any of the grades from CGEB to CG4 is packaged under the grade CGN (Non-specified). 6. Coorg cardamom is segregated according to colour: 1 – golden to light cream; 2 – cream; 3 – light green to green; 4 – brownish. Where the cardamom are of no uniform colour, there is no mention of colour on the label. Agmark Schedule III for bleached or half b leached cardamom
Grade Empty and malformed capsules (%) 0.0 Immature and shrivelled capsules (%) 0.0 Size (diameter of sieve hole) (mm) 8.50 Weigh t (G/L) General characteristics
BL1
340
BL2 BL3 BL Non specified
0.0 0.0 10.0
0.0 0.0 15.0
7.00 5.00 5.0
340 300
The cardamom is fully developed, dried capsules of Elleteria cardamom, bleached and/or half bleached by sulphuring. Colour ranging from pale cream to white. Global or three cornered with skin ribbed or smooth. The capsules are free of insect infestation and visible mould. Thrip marks on the capsules do not lead to the conclusion that the capsules are infested with insects.
Definition of terms 1. Empty and malformed capsules : Capsules which have no seeds or are scanty filled with seeds. To measure this, 100 capsules are selected at random from the sample, opened and the number of empty and malformed capsules are counted. 2. Immature and shrivelled capsules : Capsules which are not fully developed. 3. BL Non-specified : Cardamom that does not conform to grades BL1 to BL3 is packed under the grade BLN. 4. Cardamom are packed separately according to whether they are fully bleached or half bleached. In the latter case the colour of the capsules may be indicated at the request of the packer; 1- pale creamy; 2 – dull white. 5. The word special can be affixed to grades BL1 and BL2 if at least 95% f the capsules do not have thrip marks over 50% of their body surface.
5
Post a Comment